Vw Thing Fuse Box Diagram
Fuse box diagram (fuse layout), location, and assignment of fuses and relays Volkswagen New Beetle (9C) (1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010).
Checking and Replacing Fuses
The fuses are designed to blow before the entire wiring harness is damaged. If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary.
- Switch off the headlights, the ignition, and all electrical consumers.
- Open the appropriate fuse box.
- See diagrams below for details about which fuse to check.
- Remove the fuse using the plastic tweezers located on the fuse box cover.
- Check if the fuse is blown – if the thin metal strip inside is broken, the fuse has blown.
- If the fuse is blown, replace the fuse with a new fuse of the same amperage (same color and same imprint) and the same overall size.
- Replace the cover.
Notice
- Never replace a fuse with one that has a higher amp rating. Replace a blown fuse only with a fuse of the same amperage (same color and same imprint) and the same overall size.
- Never repair fuses.
- Never replace fuses with a metal strip, a paper clip, or a similar object.
- If a newly replaced fuse blows again after a short time, the electrical system should be checked by an authorized Volkswagen dealer or an authorized Volkswagen Service Facility.
Location
- Fuses on fuse holder/battery
- Fuses position additional relay carrier above the relay plate
- Fuses in fuse holder on the left dash panel
Engine Compartment Fuse Box
The fuses are on the battery.
| № | A | Function/component |
|---|---|---|
| 1 | 50 | V101 - Secondary air pump motor, models with secondary air pump only |
| J359 - Low heat output relay, models with diesel engines, manual gearbox only | ||
| J360 - High heat output relay, models with diesel engines, manual gearbox only | ||
| 2 | 50 | J17 - Fuel pump relay (17/30) |
| J370 - Glow plug activation control unit, models with diesel engines only | ||
| 3 | 40 | J293 - Radiator fan control unit (T4e/1) |
| V7 - Radiator fan | ||
| 4 | 110 | J59 - X - contact relief relay (7/30) |
| 5 | 110 | C - Alternator (90A) |
| 150 | C - Alternator (120A) | |
| 6 | 30 | J104 - ABS control unit (T47a/1) |
| 7 | 30 | J104 - ABS control unit (T47a/32) |
| 8 | 30 | F18 - Radiator fan thermal switch |
| J293 - Radiator fan control unit (T4e/3) |
Passenger Compartment Fuse Box
The fuse panel is located behind the cover on the driver's side of the dashboard.
| № | A | Function/component |
|---|---|---|
| 1 | 10 | J99 - Heated exterior mirror relay (*1) |
| J131 - Heated driver seat control unit (T6/5) | ||
| J132 - Heated front passenger seat control unit (T6b/5) | ||
| W6 - Glove compartment light | ||
| Z20/ Z21 - Left/right washer jet heater element | ||
| 2 | 10 | J1 - Turn signal relay (T7/6) |
| M5/ M7 - Front left/right turn signal bulb | ||
| M6/ M8 - Rear left/right turn signal bulb | ||
| 3 | 5 | E1 - Lighting switch |
| E20 - Switches and instruments illumination regulator | ||
| J5 - Fog light relay (4/86) | ||
| 4 | 5 | X - number plate light |
| 5 | 7.5 | E45 - Cruise control system switch (*2) |
| E159 - Fresh air/air recirculation flap switch (T8b/5) | ||
| E184 - Fresh air and air recirculation switch (*1) | ||
| E227 - Cruise control system (CCS) SET button (T4q/3), CCS only (*1) | ||
| E231 - Exterior mirror heater button | ||
| F36 - Clutch pedal switch (T4q/3) | ||
| F47 - Brake pedal switch | ||
| G65 - High-pressure sender (T3e/3) | ||
| J89 - Daytime running lights change-over relay (8/86) | ||
| J255 - Climatronic control unit (T16c/9) (*1) | ||
| J293 - Radiator fan control unit (T14/9) | ||
| J386 - Driver door control unit (T18d/3) | ||
| T16 - 16-pin connector, self-diagnosis (T16/1T16/16) | ||
| V48 - Left headlight range control motor (*1) | ||
| V49 - Right headlight range control motor (*1) | ||
| Y2 - Digital clock (*2) | ||
| Y7 -Automatic anti-dazzle interior mirror (*2) | ||
| 6 | 5 | J393 - Convenience system central control unit (T23/5) |
| Vacant, model year 2004 | ||
| 7 | 10 | F4 - Reversing light switch |
| F125 - Multifunction switch (T10t/10) (*2) | ||
| G22 - Speedometer sender | ||
| J226 - Starter inhibitor and reversing light relay (T9/5) | ||
| K142 - Selector lever position P/N warning lamp | ||
| M16 / M17 - Left/right reversing light bulb | ||
| T16 - 16-pin connector, self-diagnosis (T16/1) | ||
| 8 | - | Vacant |
| J412 - Mobile telephone operating electronics control unit (T18d/10) (*3) | ||
| 9 | 5 | E256 - TCS and ESP button (T6/6) |
| J104 - ABS control unit (T47a/4) | ||
| G85 - Steering angle sender (T6k/5) | ||
| 10 | 10 | J285 - Control unit in dash panel insert (T32/30) |
| J393 - Convenience system central control unit (T23/17), models with window regulator from 2003 only | ||
| R - Radio | ||
| Y2 - Digital clock | ||
| 11 | 5 | J285 - Control unit in dash panel insert (T32/1) |
| N110 - Selector lever lock solenoid | ||
| 12 | 7.5 | T16 - 16-pin connector, self-diagnosis (T16/16) |
| J502 - Tyre pressure monitor control unit (T20b/3) (*2) | ||
| 13 | 10 | F - Brake light switch |
| 14 | 10 | J220 - Motronic control unit (T121/62) |
| J271 - Motronic current supply relay | ||
| J393 - Convenience system central control unit (T23/22), models with window regulator from model year 2003 | ||
| 15 | 5 | G85 - Steering angle sender (T6p/4) for TCS/ESP |
| J217 - Automatic gearbox control unit (T68/45) | ||
| J285 - Control unit in dash panel insert (T32/23) | ||
| Y2 - Digital clock (*2) | ||
| 16 | 10 | J293 - Radiator fan control unit (T14/4) |
| 17 | - | Vacant |
| 18 | 10 | J5 - Fog light relay |
| J285 - Control unit in dash panel insert (T32/a17) | ||
| J607 - Right dip and main beam switch relay (for gas discharge bulb) (*1) | ||
| M32 - Right main beam bulb | ||
| 19 | 10 | J606 - Left dip and main beam switch relay (for gas discharge bulb) (*1) |
| M30 - Left main beam bulb | ||
| 20 | 15 | J607 - Right dip and main beam switch relay (for gas discharge bulb) (*1) |
| M31 - Right headlight dipped beam bulb | ||
| 21 | 15 | J606 - Left dip and main beam switch relay (for gas discharge bulb) (*1) |
| M29 - Left headlight dipped beam bulb | ||
| 22 | 5 | J285 - Control unit in dash panel insert (T32/26) |
| M3 - Right side light bulb (*2) | ||
| M22 - Right brake and tail light bulb | ||
| M34 - Front right side marker bulb (*2) | ||
| M36 - Front right turn signal and side marker bulb | ||
| M38 - Rear right side marker bulb | ||
| 23 | 5 | J285 - Control unit in dash panel insert (T32/27) |
| M1 - Left side light bulb (*2) | ||
| M21 - Left brake and tail light bulb | ||
| M33 - Front left side marker bulb (*2) | ||
| M35 - Front left turn signal and side marker bulb | ||
| M37 - Rear left side marker bulb | ||
| 24 | 20 | E22 - Intermittent wiper switch (T8c/8) |
| J31 - Automatic intermittent wash and wipe relay (T18a/13), for headlight washer system only | ||
| 25 | 25 | E9 - Fresh air blower switch (T6d/2) |
| J255 - Climatronic control unit (T16b/14) (*1) | ||
| V2 - Fresh air blower, for Climatronic only (*1) | ||
| 26 | 25 | E15 - Heated rear window switch (T6b/5) |
| Z1 - Heated rear window | ||
| 27 | 15 | U1 - Cigarette lighter, from model year 2007 |
| J29 - Blocking diode, from model year 2007 | ||
| U18 - 12 V socket -2- | ||
| U19 - 12 V socket 3, in luggage compartment | ||
| 28 | 15 | G6 - Fuel system pressurisation pump |
| J17 - Fuel pump relay (T9b/1) (*3) | ||
| 29 | 15 | J220 - Motronic control unit (T121/3) |
| J248 - Diesel direct injection system control unit (T121/37) (*1) | ||
| N30/ N31/ N32/ N33/ N83 - Injector, cylinder (*2) | ||
| J623 - Engine control unit (T80/4), engine code CBPA only (*2) | ||
| G70 - Air mass meter, (T5d/2), engine code BEW only, from June 2003 up to December 2006 | ||
| J248 - Diesel direct injection system control unit, (T94/18), engine code BEW only, from June 2003 up to December 2006 | ||
| 30 | 20 | J245 - Sliding sunroof adjustment control unit (T6l/4) |
| 31 | 20 | F125 - Multifunction switch (T8a/7) (*1) |
| J217 - Automatic gearbox control unit (T68/23) | ||
| J539 - Brake servo control unit (T6k/3) | ||
| 32 | 30 | N30/ N31/ N32/ N33 - Injector, cylinders, engine code CBPA only |
| N280 - Air conditioning system compressor regulating valve (*2) | ||
| 32 | 15 | J248 - Diesel direct injection system control unit (T121/2) |
| N146 - Metering adjuster (*1) | ||
| 33 | 20 | Vacant |
| 34 | 10 | G40 - Hall sender, engine code BEW only, from June 2003 up to December 2006 |
| J52 - Glow plug relay (engine codes ALH and BEW only) | ||
| J299 - Secondary air pump relay (T13/9) (*3) | ||
| J370 - Glow plug activation control unit, (6/87), engine code BEW only, from June 2003 up to December 2006 | ||
| N18 - Exhaust gas recirculation valve (engine codes ALH and BEW only) | ||
| N75 - Charge pressure control solenoid valve | ||
| N79 - Heater element for crankcase breather (*3) | ||
| N108 - Commencement of injection valve (engine codes ALH and BEW only) | ||
| N239 - Variable intake manifold flap change-over valve (engine codes ALH and BEW only) | ||
| N205 - Inlet camshaft control valve 1 (engine codes ALH and BEW only) | ||
| N249 - Turbocharger air recirculation valve (engine codes ALH and BEW only) | ||
| N345 - Exhaust gas recirculation cooler change-over valve, engine code BEW only, from June 2003 up to December 2006 | ||
| S130 - Secondary air pump fuse (*3) | ||
| V157 - Intake manifold flap motor, engine code BEW only, from June 2003 up to December 2006 | ||
| 35 | 30 | U19 - 12 V socket 3, in luggage compartment |
| U10 - Trailer socket (T13/9) (*3) | ||
| 36 | 15 | E7 - Fog light switch (T17/2) |
| 37 | 20 | J220 - Motronic control unit (T121/62) |
| J248 - Diesel direct injection system control unit (T121/88), engine codes ALH and BEW | ||
| J271 - Motronic current supply relay (1/30) | ||
| J393 - Convenience system central control unit (T23/17), models with window regulator | ||
| J623 - Engine control unit (T80/15), engine code CBPA only | ||
| S283 - Brake vacuum pump fuse | ||
| 38 | 15 | E204 - Tank filler flap remote release switch |
| E233 - Rear lid remote release button | ||
| J386 - Driver door control unit (T29/19), models with window regulator | ||
| J387 - Front passenger door control unit (T29a/19), models with window regulator | ||
| J393 - Convenience system central control unit (T23/22) (*3) | ||
| 39 | 15 | E3 - Hazard warning light switch (T8d/8) |
| 40 | 20 | H1 - Horn or dual tone horn |
| J4 - Dual tone horn relay (3/30) | ||
| 41 | 15 | U1 - Cigarette lighter |
| U5 - 12 V socket | ||
| U18 - 12 V socket -2-, from 07.03 | ||
| U19 - 12 V socket 3, in luggage compartment, from 07.03 | ||
| Vacant (*3) | ||
| 42 | 25 | R - Radio (T8/5, T8/7) |
| 43 | 10 | G39 - Lambda probe |
| G70/G42 - Air mass meter/ Intake air temperature sender, engine codes BPS, BPR only | ||
| G108 - Lambda probe 2 | ||
| G130 - Lambda probe after catalytic converter | ||
| G465 - Centre Lambda probe for bank 1 catalytic converter, engine code BPR only | ||
| J299 - Secondary air pump relay (4/85) (*1) | ||
| N80 - Activated charcoal filter system solenoid valve 1 | ||
| N112-Secondary air inlet valve (*1) | ||
| V144 - Fuel system diagnostic pump | ||
| 43 | 10 | F36 - Clutch pedal switch |
| F47-Brake pedal switch | ||
| J359 - Low heat output relay | ||
| J360 - High heat output relay | ||
| N79-Heater element for crankcase breather | ||
| 44 | 15 | J131 - Heated driver seat control unit (T6/4) |
| J132 - Heated front passenger seat control unit (T6b/4) | ||
| *1 - model year 2002 up to july 2005 *2 - from model July 2005 *3 - from model July 2009 | ||
Relay Panel
It is in the instrument panel.
| № | A | Function/component |
|---|---|---|
| A | 30 | Window regulator thermal fuse -S43- |
| B | Brake vacuum pump fuse -S283- (*1) | |
| Vacant (*2, 7) | ||
| C | 30 (*3) | Rear spoiler motor fuse -S329- (*3) |
| 10 (*7) | Secondary air pump fuse -S130- | |
| F | - | Vacant |
| G | - | Vacant |
| H | 15 | Anti-theft alarm system fuse and immobilizer fuse -S111- (*14) |
| Telematics fuse -S338- (*5) | ||
| J | 15 (*4) | Anti-theft alarm system central locking fuse -S144- (*4) |
| 20 (*2, *6) | Brake vacuum pump fuse -S283- (*2) | |
| Fuse for dual clutch gearbox mechatronic unit -S337- (*16) | ||
| | ||
| 1 | J4 - Dual tone horn relay (53) | |
| 2 | J59 - X-contact relief relay (100) | |
| 3 | Vacant | |
| 4 | J17 - Fuel pump relay (409) | |
| J52 - Glow plug relay (103) (*8) | ||
| 5 | Automatic intermittent wash and wipe relay -J31- (377), (192), (389) | |
| | ||
| 1 | Vacant | |
| 2 | Vacant | |
| 3 | Starter inhibitor relay, clutch pedal switch -J434- (53) (*9) | |
| 4 | Fog light relay -J5- (53) | |
| 5 | Vacant | |
| 6 | Vacant | |
| 7 | Daytime running lights change-over relay -J89- (173) (*10) | |
| 8 | Heated exterior mirror relay -J99- (53) (*11) | |
| 9 | Alarm horn relay -J641- (for telematics only) | |
| 10 | Turn signals relay for anti-theft alarm -J237- (for telematics only) | |
| Radiator fan 3rd speed relay -J135- (100) (only 1.8 l-engine) | ||
| Secondary air pump relay -J299- (100) (only petrol engines, from July 2005) | ||
| Low heat output relay -J359- (100) (engine code BEW only, from June 2003 up to December 2006) | ||
| 11 | Starter inhibitor and reversing light relay -J226- (126) (only for automatic gearbox 01M) | |
| Starter inhibitor relay -J207- (176) (from model year 2005; only for 6-speed automatic gearbox 09G, with Tiptronic) | ||
| 12 | Terminal 30 voltage supply relay -J317- (109) (for engine codes BPR, BPS only; models with diesel engines only) | |
| 13 | High heat output relay -J360- (53) (engine code BEW only, from June 2003 up to December 2006) | |
| 1 - for models with manual gearbox, model year 2003 2 - models with an automatic gearbox, from model year 2004 3 - models with 1.8 l engine, the model year 2003 up to 2005 4 - up to model year 2003 5 - from model year 2004 6 - for models with engine code BEW; with dual clutch gearbox DSG 02E; from model year 2004 7 - from model July 2005 8 - engine codes ALH, ATD, AXR, BSW only 9 - only manual gearbox 10 - daytime running lights only 11 - American markets only; only models with mechanical window regulator | ||
This website uses cookies to improve your experience. We'll assume you're ok with this, but you can opt-out if you wish. Cookie settingsACCEPT
Posted by: lavoniameshelliee.blogspot.com
Source: https://fusecheck.com/volkswagen/volkswagen-new-beetle-1997-2010-fuse-diagram